欢迎进入济南济柴环能燃气发电设备北京幸运28官网!

公司新闻

沼气发电机组增压器漏油故障分析

返回 2020.06.01 来源:http://www.nolaughing.net
  01.增压器加压气体端漏油是由于壳体出口油气积聚造成的
  01. The oil leakage at the compressor end of the supercharger is caused by the accumulation of oil and gas at the outlet of the shell
  首先,检查增压器,确认它是合格的产品。一般情况下,可以从增压器的使用情况来分析。如果使用环境中的粉尘较大,会导致空气滤清器堵塞,负压达到5.5kpa以上,导致增压器加压气体端漏油。车是在一个山坡时,沼气发电机组将推动以较低的速度超过15分钟不加油门,和气体密封的中压增压器的叶轮也将导致石油泄漏在加压气体增压器。只要定期维护空过滤器,沼气发生器空转时间不太长,就可以消除误漏油现象。如果环境建设的运行状态不能改变,只要经常从空气中灰尘过滤器移除,和油渍出口压壳的增压器和加压的出口管壳中,这种虚假的石油泄漏不会影响沼气发电机组的正常使用。
沼气发电机组
  First, check the supercharger to make sure it is qualified. In general, it can be analyzed from the use of supercharger. If the dust in the use environment is large, the air filter will be blocked, and the negative pressure will reach more than 5.5kpa, which will lead to oil leakage at the end of the supercharger's pressurized body. When the car is on a hillside, the biogas generator set will push at a lower speed for more than 15 minutes without filling the valve, and the gas sealed impeller of the medium pressure supercharger will also cause oil leakage in the pressurized gas supercharger. As long as the air filter is maintained regularly and the running time of the biogas generator is not too long, the phenomenon of accidental oil leakage can be eliminated. If the operation state of the environmental construction cannot be changed, as long as the dust filter in the air is often removed, and the supercharger and pressurized outlet pipe shell of the oil stained outlet pressure shell, the false oil leakage will not affect the normal use of the biogas generator set.
  02.过大的油压会导致增压器漏油
  02. Excessive oil pressure will cause oil leakage of supercharger
  增压器进油压力过高是造成增压器漏油的原因之一。当我们确认增压器是检验后合格的产品,并发现沼气发电机组的油压远远高于规范,有必要检查沼气发电机组的润滑系统,压力调节阀是否坚持与否,沼气发电机组的油压是正常的,可以消除增压器漏油。
  One of the reasons for the oil leakage of supercharger is that the oil inlet pressure of supercharger is too high. When we confirm that the supercharger is a qualified product after inspection, and find that the oil pressure of the biogas generator set is far higher than the specification, it is necessary to check whether the lubrication system and pressure regulating valve of the biogas generator set adhere to or not, and the oil pressure of the biogas generator set is normal, which can eliminate the oil leakage of the pressurizer.
  03.回油不良会导致增压器漏油
  03. Poor oil return will cause oil leakage of supercharger
  增压机的回油是由增压机的回油管回油到沼气发电机组的油的重量。如果回油管出现收缩和堵塞,则增压器回油不畅通,增压器两端漏油。应排除回油不自由,在增压器状态良好时,故障也排除了。
  The return oil of supercharger is the weight of the oil returned from the return pipe of supercharger to the biogas generator set. If the oil return pipe shrinks and is blocked, the oil return of the supercharger is not smooth, and both ends of the supercharger leak oil. It should be ruled out that the oil return is not free. When the supercharger is in good condition, the fault is also eliminated.
  04.沼气发电机组在建设过程中经常停运和启动
  04. The biogas generator unit is often stopped and started in the construction process
  在沼气发电机组的建设过程中,经常会出现停机、起动等现象,造成增压器中壳涡轮端部烧焦。同时,还会引起中间壳体回油腔的结焦,使增压器回油腔减少回油故障,产生漏油。检查易损件是否完好,清除结焦。
  In the construction process of biogas generator set, there are often shutdown, start-up and other phenomena, which cause the end of the shell turbine in the supercharger to burn. At the same time, it will also cause coking in the oil return cavity of the intermediate housing, so that the oil return cavity of the supercharger can reduce the oil return fault and generate oil leakage. Check whether the vulnerable parts are in good condition and remove the coking.
  05.甲烷发生器机组窜气会造成增压器油严重回流,造成增压器油泄漏
  05. Blowby of methane generator unit will cause serious backflow of supercharger oil, resulting in oil leakage of supercharger
  发现一些涡轮增压器漏油事件甚至两端和检查增压器是合格产品,饲料油是正常的,然后检查发现涡轮增压器轴中间(2)浮动轴承有一个很厚的油垢和一些困难,去除清洗后发现轴中间转淡黄色和涡轮增压器回油管油垢,从上述现象对沼气发生器设置气体增压器。更换四个配套的沼气发电机组,将沼气发电机组底部的气体排出,并清洗增压器和回油管。故障可以消除。
  It is found that some turbocharger oil leakage events and even both ends of the turbocharger are qualified products and feed oil is normal. Then it is found that there is a very thick oil scale and some difficulties in the floating bearing in the middle of the turbocharger shaft (2). After cleaning, it is found that the middle of the shaft turns light yellow and the oil scale in the oil return pipe of the turbocharger is removed. From the above phenomena, a gas supercharger is set for the biogas generator. Replace four matching biogas generator sets, discharge the gas at the bottom of the biogas generator set, and clean the supercharger and oil return pipe. Faults can be eliminated.
  以上是沼气发电机组公司小编为大家介绍的相关内容,想要了解更多内容,欢迎访问网站:http://www.nolaughing.net
  The above is a brief introduction of biogas generator set company. If you want to know more, please visit the website: http://www.nolaughing.net
新闻搜索
济南济柴环能燃气发电设备北京幸运28(版权所有)

沼气发电机组增压器漏油故障分析

  01.增压器加压气体端漏油是由于壳体出口油气积聚造成的
  01. The oil leakage at the compressor end of the supercharger is caused by the accumulation of oil and gas at the outlet of the shell
  首先,检查增压器,确认它是合格的产品。一般情况下,可以从增压器的使用情况来分析。如果使用环境中的粉尘较大,会导致空气滤清器堵塞,负压达到5.5kpa以上,导致增压器加压气体端漏油。车是在一个山坡时,沼气发电机组将推动以较低的速度超过15分钟不加油门,和气体密封的中压增压器的叶轮也将导致石油泄漏在加压气体增压器。只要定期维护空过滤器,沼气发生器空转时间不太长,就可以消除误漏油现象。如果环境建设的运行状态不能改变,只要经常从空气中灰尘过滤器移除,和油渍出口压壳的增压器和加压的出口管壳中,这种虚假的石油泄漏不会影响沼气发电机组的正常使用。
沼气发电机组
  First, check the supercharger to make sure it is qualified. In general, it can be analyzed from the use of supercharger. If the dust in the use environment is large, the air filter will be blocked, and the negative pressure will reach more than 5.5kpa, which will lead to oil leakage at the end of the supercharger's pressurized body. When the car is on a hillside, the biogas generator set will push at a lower speed for more than 15 minutes without filling the valve, and the gas sealed impeller of the medium pressure supercharger will also cause oil leakage in the pressurized gas supercharger. As long as the air filter is maintained regularly and the running time of the biogas generator is not too long, the phenomenon of accidental oil leakage can be eliminated. If the operation state of the environmental construction cannot be changed, as long as the dust filter in the air is often removed, and the supercharger and pressurized outlet pipe shell of the oil stained outlet pressure shell, the false oil leakage will not affect the normal use of the biogas generator set.
  02.过大的油压会导致增压器漏油
  02. Excessive oil pressure will cause oil leakage of supercharger
  增压器进油压力过高是造成增压器漏油的原因之一。当我们确认增压器是检验后合格的产品,并发现沼气发电机组的油压远远高于规范,有必要检查沼气发电机组的润滑系统,压力调节阀是否坚持与否,沼气发电机组的油压是正常的,可以消除增压器漏油。
  One of the reasons for the oil leakage of supercharger is that the oil inlet pressure of supercharger is too high. When we confirm that the supercharger is a qualified product after inspection, and find that the oil pressure of the biogas generator set is far higher than the specification, it is necessary to check whether the lubrication system and pressure regulating valve of the biogas generator set adhere to or not, and the oil pressure of the biogas generator set is normal, which can eliminate the oil leakage of the pressurizer.
  03.回油不良会导致增压器漏油
  03. Poor oil return will cause oil leakage of supercharger
  增压机的回油是由增压机的回油管回油到沼气发电机组的油的重量。如果回油管出现收缩和堵塞,则增压器回油不畅通,增压器两端漏油。应排除回油不自由,在增压器状态良好时,故障也排除了。
  The return oil of supercharger is the weight of the oil returned from the return pipe of supercharger to the biogas generator set. If the oil return pipe shrinks and is blocked, the oil return of the supercharger is not smooth, and both ends of the supercharger leak oil. It should be ruled out that the oil return is not free. When the supercharger is in good condition, the fault is also eliminated.
  04.沼气发电机组在建设过程中经常停运和启动
  04. The biogas generator unit is often stopped and started in the construction process
  在沼气发电机组的建设过程中,经常会出现停机、起动等现象,造成增压器中壳涡轮端部烧焦。同时,还会引起中间壳体回油腔的结焦,使增压器回油腔减少回油故障,产生漏油。检查易损件是否完好,清除结焦。
  In the construction process of biogas generator set, there are often shutdown, start-up and other phenomena, which cause the end of the shell turbine in the supercharger to burn. At the same time, it will also cause coking in the oil return cavity of the intermediate housing, so that the oil return cavity of the supercharger can reduce the oil return fault and generate oil leakage. Check whether the vulnerable parts are in good condition and remove the coking.
  05.甲烷发生器机组窜气会造成增压器油严重回流,造成增压器油泄漏
  05. Blowby of methane generator unit will cause serious backflow of supercharger oil, resulting in oil leakage of supercharger
  发现一些涡轮增压器漏油事件甚至两端和检查增压器是合格产品,饲料油是正常的,然后检查发现涡轮增压器轴中间(2)浮动轴承有一个很厚的油垢和一些困难,去除清洗后发现轴中间转淡黄色和涡轮增压器回油管油垢,从上述现象对沼气发生器设置气体增压器。更换四个配套的沼气发电机组,将沼气发电机组底部的气体排出,并清洗增压器和回油管。故障可以消除。
  It is found that some turbocharger oil leakage events and even both ends of the turbocharger are qualified products and feed oil is normal. Then it is found that there is a very thick oil scale and some difficulties in the floating bearing in the middle of the turbocharger shaft (2). After cleaning, it is found that the middle of the shaft turns light yellow and the oil scale in the oil return pipe of the turbocharger is removed. From the above phenomena, a gas supercharger is set for the biogas generator. Replace four matching biogas generator sets, discharge the gas at the bottom of the biogas generator set, and clean the supercharger and oil return pipe. Faults can be eliminated.
  以上是沼气发电机组公司小编为大家介绍的相关内容,想要了解更多内容,欢迎访问网站:http://www.nolaughing.net
  The above is a brief introduction of biogas generator set company. If you want to know more, please visit the website: http://www.nolaughing.net
秒速快3 玖玖棋牌app 上海时时乐开奖 欢乐生肖 欢乐生肖 快乐赛车官网 彩票高賠率好平台 易发彩注册 北京幸运28 澳洲幸运8